BENDIX MC-12 MODULATOR CONTROLLER ASSY Guía para resolver problemas descargar pdf (Pagina 62)

More info: visit www.bendix.com 1-800-AIR-BRAKE (1-800-247-2725)

Air Brake System Troubleshooting Tests (continued)

TEST 2

Leakage (reservoir air supply)

For additional information refer to video Assessing Air Brake System Air Leakage (BW2327 - CD)

Full pressure, engine stopped, parking brakes applied

Not

1. Allow the air pressure to stabilize for at least 1 minute.

Observe the dash gauge pressures for 2 minutes and note any pressure drop.

A. Pressure Drop: Single Vehicle

(A 4 psi drop within 2 minutes is allowable for either service reservoir)

B. Pressure Drop: Tractor/Trailer

(A 6 psi drop within 2 minutes is allowable for either service reservoir)

C. Pressure Drop: Tractor/2 Trailers

(An 8 psi drop within 2 minutes is allowable for either service reservoir)

Make all the necessary repairs before proceeding to test 3; see checklist 2 for common corrections.

CHECKLIST 2

If there is excessive leakage in the supply side of

the pneumatic system, one or more of the following

devices could be causing the problem:

NOTE: A leak detector or soap solution will aid in locating the faulty

component.

1. Supply lines and ﬁ ttings

2. Low pressure indicator(s)

3. Service brake relay valve(s)

4. Spring brake relay valve (where applicable)

5. Dual brake valve

6. Trailer hand control valve

7. Parking control valve

8. System safety valve(s) in the supply reservoir and/or air

dryer

9. Governor (may be mounted on the air dryer as illustrated, on

the compressor, or remotely).

10. Compressor discharge line

Retest to verify proper operation of all items repaired

or replaced.

Make and hold brake application. When ignition power is applied,

each modulator solenoid is brieﬂ y energized. If the air system is

fully charged and the service brake pedal is depressed during

ignition, the modulator creates a single, sharp audible “chuff” of

air pressure. The modulators are energized in a certain pattern,

as follows: right front, left front, right rear, left rear. This test is

performed only when the vehicle is stationary (if the vehicle

moves the chuff test will not be performed).

NOTE: The EC-60

™

controller will perform a PMV chuff test on all

installed modulators in the following order:

1. Steer Axle Right PMV

2. Steer Axle Left PMV

3. Drive Axle Right PMV

4. Drive Axle Left PMV

5. Additional Axle Right PMV

6. Additional Axle Left PMV

7. Drive Axle TCV

The pattern will then repeat itself.

See appropriate Service Data Sheet for repairs.

Make all necessary repairs before proceeding to

Test 4.

TEST 3

Pressure Modulator Valve and Traction Control Valve Chuff Test

Full pressure, engine stopped, parking brakes released

1 2 ... 57 58 59 60 61 62 63 64 65 66 67 68 69 70

Comentarios a estos manuales

Sin comentarios

Samsung RL60GZEIH User Manual (16 pages)

Brand: Samsung | Category: No info | Size: 8.62 MB |

Refrigerator

Safety information

CAUTION SIGNS FOR

CLEANING AND MAINTENANCE

SEVERE WARNING SIGNS

FOR DISPOSAL

Contents

Setting up your refrigerator

REVERSING THE DOOR

8_ Setting up

LEVELLING THE REFRIGERATOR

Operating your refrigerator

MAKING ICE

USING THE WATER DISPENSER

(OPTIONAL)

REMOVING THE INTERIOR PARTS

CLEANING THE REFRIGERATOR

REPLACING THE LED LAMP

Troubleshooting

Circuit diagram

Contact SAMSUNG WORLD WIDE

More products and manuals for Unknown Samsung

Models	Document Type
SM-R380	User Manual Samsung SM-R380 Manual do usuário, 65 pages
RL27TEFSW	User Manual Samsung RL27TEFSW User manual, 12 pages
RS263TDWP	User Manual Samsung RS263TDWP User manual, 68 pages
RL33EA	User Manual Samsung RL33SBSW Manuel utilisateur, 9 pages
RSG5FURS	User Manual Samsung RSG5FURS Guide de démarrage rapide, 17 pages
RF265AA	User Manual Samsung RF265AA User manual, 38 pages
RFG238	User Manual Samsung RFG238 User manual, 100 pages
Freezer	User Manual Samsung Freezer User manual, 24 pages
SV-232B	User Manual Katalog für iPad oder Mac/PC [en] , 164 pages
DA99-00478C	Operations Instructions Samsung DA99-00478C Operating instructions, 37 pages
YP-VP1	User Manual Samsung YP-VP1AS User manual, 59 pages
TX21B5DF3X/XEE	User Manual Secure IP Address Management Layer 2 Network Access Control, 8 pages
CL-21Z30MQL	Service Manual Samsung CL-21Z30MQL Service manual, 41 pages
SP0812N	Installation Guide Samsung SP0812N Installation guide, 1 pages
RL32CS	User Manual Samsung RL32CS User manual, 20 pages
RS21H	User Manual Samsung RS21HVLPM ユーザーマニュアル, 44 pages
SR-V52	User Manual S6D0144 - NewHaven Display [en] , 144 pages
RF323TE	User Manual Before calling service, 2 pages
RS25H5111	User Manual Samsung RS25H5111 User manual, 96 pages
RS20NCSL	User Manual Samsung RS20NCSL Manuel utilisateur, 16 pages